Search results

Hey guys, I have read that gu patrol calipers fit on a d22? Is there any point in fitting/upgrading to these? Going off bendix website the brake pads are almost identical in dimensions. Both are a twin piston? I feel like there would be bugger all brake performance increase between the two...

Hi Guys, So occasionally I have been getting the dreaded 0707 error code which often occurs with pump fair or air in fuel lines or dirty fuel. I believe its the original pump at 190k so who knows it could go at any second haha. The fuel is fine I have checked, there is new filter on there. So...

Hey Guys, Looking to make the inside of d22 dual cab cabin a bit quieter. Most of the noise I get is engine noise/road noise. I'm looking at some of this cheap pingjing sound deadener on ebay which comes with a roller applicator for about 200 bucks which should cover the floor and rear wall of...

Hey Guys, I have picked up a second hand long range tank. It has been pretty empty for a while and in the bottom there is a layer of rust (I assume) which was covered by diesel, the sides are clean. I can manually clean the middle section which has the fuel sender as you can reach in, however...

Hey Guys, So I have come across a problem which has stumped me. Basically I did a trip to the cape and destroyed two radiators because I had a busted transmission mount and whenever the car was in low range first gear the engine would torque up and smash into the top of the radiator and the...

Okay guys, I have what seems to be an electronic gremlin. Yesterday I was getting a sober driver to drove my d22 home for me. When the ignition was switched it conked out three times before I got running correctly and then made it home no dramas. Today I went to flick the ignition. What...

Hey Guys, I am in need of another spare for my cape york trip as pre caution as it seems most people take two spares. I currently have yokohama 265/75/16s on the car they are D load range and only 8 play (wish I got 10 ply but oh well, bought them before I knew about tyres and got a decent...

Hey guys I need some urgent help. I have just fitted a patrol manifold rocker cover and vacuum/solenoid bracket to fit a patrol intercooler. In the process to remove the d22 manifold I had to remove the injection pipes. Upon putting it all back together I cannot get it to fire up. I have done...

Hey Guys. Just wondering if anyone has replaced their zd30 starter motor with anything but OEM? I went to an auto leccy and he said it will be $500 for the unit plus fitting, he says they use as good if not better than OEM (I know that sounds liek BS, but he is a mate of mine). Supercheap want...

Hey Guys, Got this metallic scrapping noise coming from my front drivers wheel, only started happening after a recent trip over to Fraser Island last week. Things to note: It happens in 2H,4H and 4L When I was on the island it was happening all the time on and off constantly, now is only...

Okay guys, So I cant do a FMIC as I have an 80 series airbox so that means my only other option is a TMIC. I have seen some homemade versions but they are all super squishy and often cover the oil cap which is a pain in the ass for servicing. So what I want to do is a fit a GU TMIC to my D22...

Okay so I know you cant permanently mount a full length roof tray to both the canopy/tub and the cab. But what if you mount the roof tray to the canopy/tub with internal frame and then just rest the roof tray on the cabin roof racks, ie dont fix the front of the roof tray down just rest it...

Have had a knocking sound from my front left hand side since I bought my nav. here is the video to show the source of the noise. I have removed and re tightened the body mount way above factory torque settings and it has stopped the noise for now, see how long it lasts though. https://vid.me/yv3N

Okay so I have been doing some research into an alloy canopy (1800x1800x800ish) to mount to a tray for my touring set up to go to the cape and gibb river etc. I tend to like the look of the flat plate canopies that are painted. I am just not keen to tow a camper offroad, however there are plenty...

So I have come to realise that my bilstein 4600 two inch lift shocks don't give a whole lot of down travel and I am assuming they are the limiting factor. I see people who run three inch lift patrol shocks. However the closed length on these limit up travel. Is there any negative about running...

Okay guys, I recently installed a boost gauge from Auber instruments seen here http://www.auberins.com/index.php?main_page=product_info&cPath=5_26&products_id=226 coupled with their 3 bar MAP sensor for diesel engine...

Hey Guys, So I finally got my Auber instruments EGT gauge from the states. I have a couple of questions. With the EGT gauge I opted for the 1/8th NPT fitting as I have already had a SS plate (with a central tap at 1/8NPT made my someone else) to go over the EGR port on the manifold for the...

Hey guys, So I have had these two squeaking type noises coming from my dash lately and then drive me bloody crazy. I did a bit of research and stumbled across a forum where someone sprayed some silicon spray down the front of the dash between the front most join and windscreen. I gave it a...

Okay so I have been doing some research into this and a couple of people have done this already, but there are different ways to go about it, the easiest way there I can think to do it seems logical but I am not sure if anyone has done it. Options: 1. Get a Dana 44 diff and put it under the...

Hey Guys, So recently (last month or so) my D22 has become more and more difficult to start, to the point of tonight finally throwing an error code. It now takes about 5-8 seconds of solid cranking and it finally splutters to life and the fault light comes on. So basically this seems to have...